5
Maintaining
Your Lawn
Mower
Deck Care
Clean underside of the mower deck after each use to
prevent build-up of grass clippings or other debris. Follow
steps below for this job.
1.
2.
Disconnect spark plug wire. Drain gasoline from lawn
mower or place a piece of plastic under the gas cap.
Tip mower so that it rests on the engine. Keep the side
with the air cleaner facing up. Hold mower firmly.
WARNING: Never tip the mower more
than 90º in any direction and do not
leave the mower tipped for any length of
time. Oil can drain into the upper part of the engine
causing a starting problem.
3.
4.
Scrapesuitableandtool.cleanDo notthesprayundersidewith water.of the deck with a
Put the mower back on its wheels on the ground. If
you had put plastic under the gas cap earlier, make
sure to remove it now.
Figure 5-1: Areas to lubricate on mower.
WARNING
General Recommendations
Always stop engine,
disconnect spark
plug, and ground
against engine before
performing any type
of maintenance on
your machine.
•
Always observe safety rules when performing
any maintenance.
Engine Care
•
The warranty on this lawn mower does not cover
items that have been subjected to operator abuse
or negligence. To receive full value from warranty,
operator must maintain the lawn mower as
instructed here.
A list of key engine maintenance jobs required for good
performance by the mower is given below. Follow the
accompanying engine manual for a detailed list and
instructions.
•
•
Maintain oil level as instructed in engine manual.
•
•
•
Changing of engine-governed speed will void
Service air cleaner every 25 hours under normal
conditions. Clean every few hours under extremely
dusty conditions. Poor engine performance and
flooding usually indicates that the air cleaner should
be serviced. To service the air cleaner, refer to the
engine manual.
engine warranty.
All adjustments should be checked at least once
each season.
Periodically check all fasteners and make sure these
are tight.
Do not use a pressure
washer or garden
•
•
Clean spark plug and reset the gap once a season.
Spark plug replacement is recommended at the start
of each mowing season. Check engine manual for
correct plug type and gap specifications.
Clean engine regularly with a cloth or brush. Keep the
top of the engine clean to permit proper air circulation.
Remove all grass, dirt, and combustible debris from
muffler area.
WARNING: Always stop engine, discon-
nect spark plug, and ground against
engine before performing any type of
hose to clean your
unit. These may cause
damage to electric
components, spindles,
pulleys, bearings, or
the engine. The use
of water will result in
shortened life and
maintenance on your machine.
Lubrication
1. Lubricate pivot points on the blade control at least
once a season with light oil. The blade control must
operate freely in both directions. See Figure 5-1.
2.
Lubricate the wheels at least once a season with
light oil (or motor oil). If wheels are removed for any
reason, lubricate surface of the pivot arm and inner
surface of the wheel with light oil. See Figure 5-1.
reduce serviceability.
This Operator’s Manual
covers several models.
Lawn Mower features
vary by model. Not
all features discussed
(or engines pictured)
in this manual are
3. Lubricate the torsion springs and pivot point on the
rear discharge door and side mulch plug periodically
with light oil to prevent rust. See Figure 5-1.
4.
Follow the accompanying engine manual for lubrica-
tion schedule and instruction for engine lubrication.
applicable to all Lawn
Mower models.
10
| Categories | Lawn Mower Manual, MTD Lawn Mower Manuals, Troy-Bilt Lawn Mower Manuals |
|---|---|
| Tags | MTD 540, Troy-Bilt 540 |
| Download File |
|
| Document Type | Owner's Manual |
| Language | English |
| Product Brand | MTD, Lawn Mower |
| Product Type | Walk Behind Mower |
| Document File Type | |
| Publisher | mtdproducts.com |
| Wikipedia's Page | MTD Products |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)