SECTION 8 - ELECTRICAL
8.1
ELECTRIC STARTER
tank neck. Measure 10" of fuel line from carburetor and
trim off excess (reference A), see Figure 12.
Electric starter is not equipped with a thermal cutout
switch. DO NOT crank engine for more than a total of
20 seconds without allowing electric starter to cool
down for 10 minutes. Failure to do this can severely
damage electric starter.
Turn eyelet on top of engine containing the green
ground wire to the two o’clock position (reference B)
and wrap a 2" piece of electrical tape 2" up from the
eyelet, taping the two wires together (reference C). On
electric start unit the green wires should be routed over
the electric start cable.
8.2
SNO-THRO CABLE ROUTING
Measure and drill a 1/8" hole in the upper right corner
of the engine blower housing 5/8" from each edge
(reference D) Figure 13. Cover carburetor before
drilling to keep particles out of carburetor throat.
Measure and drill a 3/8" hole for the primer hose 2"
down and 5/8" out of the corner (reference E). Remove
primer hose from carburetor and reroute through the
new hole and reattach to the carburetor (reference F),
see Figure 12.
IMPORTANT: This procedure should be done on all
units to prevent wiring from getting caught in the chute
crank gears.
Place the Sno-Thro on a raised work surface. Remove
ignition key, and drain all fuel from the fuel tank.
Remove the gas cap and remove the engine cowl part
#38005. Retain all hardware for reassembly later.
Remove the cable tie from the two green ignition wires
and from fuel tank support bracket. Remove the fuel
tank from the unit and retain the cable tie around the
ref. M
ref. H
ref. I
ref.A
cable tie
chute cable
cable tie
gas line hose
ref. E
drill 3/8" hole
ref. C
electric tape
ref. B
eyelet
ref. F
primer hose
Upper photo of cable routing and anchor point.
Figure 12
8
- 18
| Categories | Ariens Snow Blower Manuals, Snow Blower Manuals |
|---|---|
| Tags | Ariens 938001, Ariens 938004, Ariens 938006, Ariens 938012, Ariens 938015, Ariens 938016, Ariens 938301, Ariens 938305 |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Ariens, Snow Blower |
| Document File Type | |
| Publisher | ariens.com |
| Wikipedia's Page | Ariens |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)