IMPORTANT: Drain gasoline from a cold engine only.
8. Check the oil level and install the dipstick.
9. Wipe up any spilled oil.
2.
3.
Pull the wire off of the spark plug (Fig. 15).
Remove the cap from the fuel tank and use a
pump-type syphon to drain the fuel into a clean gas
can.
Spark Plug
Use a Champion RJ19LM spark plug or equivalent. The
correct air gap is 0.030” (0.76 mm). Remove the plug
after every 25 operating hours and check its condition.
Note: This is the only procedure recommended for
draining fuel.
1.
Stop the engine and pull the wire off the spark plug
(Fig. 15).
Change Engine Oil
Change the engine oil after the first 5 hours of operation
and after 50 hours of operation or yearly thereafter.
Change oil while the engine is warm.
2
1
WARNING
1002
m-4198
POTENTIAL HAZARD
Figure 15
•
Gasoline is extremely flammable, highly
explosive and under certain conditions can
cause personal injury or property damage.
1.
2.
Spark plug wire (Models 20022, 20023, 20025, 20029, and
20061)
Spark plug wire (Model 20027)
WHAT CAN HAPPEN
•
Tipping the mower may cause fuel leakage
from the carburetor or fuel tank.
2. Clean around the spark plug and remove it from the
cylinder head.
HOW TO AVOID THE HAZARD
•
Avoid fuel spills by running the engine dry or
removing gas with a hand pump; never siphon.
IMPORTANT: Replace a cracked, fouled, or dirty
spark plug. Do not clean the electrodes because engine
damage could result from grit entering the cylinder.
1.
Drain the gasoline from the fuel tank. Refer to the
Draining Gasoline section, page 11.
3.
Set the gap on the new plug to 0.030” (0.76 mm) (Fig.
16).
2.
3.
4.
Start the engine and let it run until it runs out of fuel.
Pull the wire off of the spark plug (Fig. 15).
.030 in.
(.76 mm)
986
Remove the dipstick and tip the mower on the left
side, draining the oil out the oil fill tube into an
appropriate container (Fig. 14).
Figure 16
4.
5.
Install the spark plug and gasket seal. Tighten the plug
to 15 ft-lb (20 N m).
1
m–-1782
Connect the spark plug wire (Fig. 15).
Figure 14
1.
Oil fill tube
Adjusting the Self-propel Cable
If the top speed begins to slow on the mower, adjust the
self–propel cable.
5.
6.
7.
Recycle the oil as per local codes.
Turn the mower upright.
1.
With the engine turned off, remove the bolt securing
the belt cover (Fig. 28) and remove the cover.
Fill the crankcase to the FULL line on the dipstick
with fresh oil. Refer to the Oil section, page 6, for
specifications.
12
| Categories | Lawn Mower Manual, Toro Lawn Mower Manual |
|---|---|
| Tags | Toro 20022, Toro 20023, Toro 20025, Toro 20027, Toro 20029, Toro 20061 |
| Model Number | 20022, 20023, 20025, 20027, 20029, 20061 |
| Model Year | 1999 |
| Download File |
|
| Document Type | Operator's Manual |
| Language | English |
| Serial Number | 9900001 - 9999999 |
| Product Name | Toro Recycler Mower, R-21S |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Product Type | Walk Behind Mower |
| Swath | 21 inch |
| Engine Manufacturer | Briggs & Stratton |
| Engine Oil Type | 20 oz. (.6l) 30w or 10w-30 / API SH or higher |
| Gearbox Lubricant | 3 oz. (92gm) #2 Lithium grease |
| Engine Motor Model # | 12H802-1767-E1 |
| Engine Motor Size | 6 hp |
| Engine Motor Type | 4 Cycle CARB1, EPA1 |
| Transmission Speed | Personal Pace |
| Transmission Type | Gear |
| Spark Plug | Champion RJ19LM |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(2 votes, average: 4 out of 4)
Lawn and Garden readers have rated Toro 20022 20023 20025 20027 20029 20061 21-Inch Lawn Mower Operators Manual, 1999 4.0 out of 4.0 based on 2 product reviews. Good mower, but has always been hard to restart after warmed up. Starts much easier with air filter removed. Suspect blocked exhaust port, and am looking for an engine manual.
Getting harder and harder to start!