MAINTENANCE AND REPAIR INSTRUCTIONS
NOTE: Use the bottle and spout saved from initial use to
measure the correct amount of oil. The top of the label
on the bottle measures approximately 3.04 ounces (90
ml) or 3/8 cup (Fig. 22). Check the level, See Checking
the Oil Level. If the level is low, add a small amount of
oil and recheck. Do not overfill (Fig. 22).
Fill Level
Fig. 25
Fig. 26
7.
8.
Reinstall the air
filter cover.
Tabs
Back Plate
Air Filter
Position the slots
on the top of the
air filter cover
onto the tabs at
the top of the
back plate (Fig.
27).
Fig. 22
Replace the oil fill plug.
6.
7.
Swing the cover
down until the tab
on the air filter
Reconnect the spark plug boot.
AIR FILTER MAINTENANCE
Locking Tab
backplate snaps
into place in the
slot on the air
Fig. 27
WARNING: To avoid serious personal injury,
always turn the unit off and allow it to cool before
you clean or service it.
filter cover (Fig. 28).
Air Filter Cover
Cleaning the Air Filter
Clean and re-oil the air filter every 10 hours of operation. It is an
important item to maintain. Failure to maintain your air filter
properly can result in poor performance or can cause
permanent damage to your engine.
Air Filter
1.
Open the air filter cover. Push the tab on the under side of
the cover inward. Then pull the air filter cover out and up.
(Fig. 23).
Air Filter Cover
Air Filter
Tab
Fig. 28
CARBURETOR ADJUSTMENT
The idle speed of the
engine is adjustable. An
idle adjustment screw is
between the air filter cover
and the engine starter
housing (Fig. 29).
Idle Adjustment Screw
NOTE: Careless
adjustments can
seriously damage
your unit. A Sears
or other qualified
service dealer
should make
Tab
Fig. 23
2.
3.
Remove the air filter (Fig. 23).
Wash the filter in detergent and
water (Fig. 24). Rinse the filter
thoroughly and allow it to dry.
Fig. 29
carburetor
4.
Apply enough clean SAE 30
motor oil to lightly coat the filter
(Fig. 25).
adjustments.
Check Fuel
5
.
Squeeze the filter to spread and
remove excess oil (Fig. 26).
Old fuel is usually the reason for improper unit performance.
Drain and refill the tank with fresh fuel prior to making any
adjustments. Refer to Oil and Fuel Information.
6.
Replace the filter (Fig. 23).
Clean Air Filter
NOTE: If the unit is operated
without the air filter, you will
VOID the warranty.
The condition of the air filter is important to the operation of
the unit. A dirty air filter will restrict air flow. This is often
mistaken for an out of adjustment carburetor. Check the
condition of the air filter before adjusting the idle speed screw.
Refer to Air Filter Maintenance.
Fig. 24
11
| Categories | Craftsman Lawn Mower Manuals, Lawn Mower Manual |
|---|---|
| Tags | Craftsman 316 796170 |
| Download File |
|
| Document Type | Operator's Manual |
| Language | English |
| Product Brand | Craftsman. Customer Service Representatives are available by phone: Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | craftsman.com |
| Wikipedia's Page | Craftsman (tools) |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)