General Information
Check Oil Level
Fill crankcase with SAE 30 oil until oil level reaches FULL
mark on dipstick as shown in Figure 1. The maximum
crankcase capacity is 22 ounces (0.65 Liter). On models
equipped with an oil filter, the maximum crankcase capacity is
26 ounces (0.78 Liter). Use any high quality detergent oil
having the American Petroleum Institute (API) “service
classification”—SF, SG SH, or SJ.
Contents
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Change Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Change Oil—Drain Plug Method . . . . . . . . . . . .
Change Oil—Oil Fill Tube Method . . . . . . . . . .
5
5
5
5
6
6
Before each use or every five hours, ensure oil level is
between ADD and FULL marks on dipstick (Fig. 1). Add oil if
level is low.
Approximate Crankcase Oil Capacity (Dry)
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1.
Position mower on level surface and clean around oil
dipstick.
6
7
Gasoline . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner – General . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tune-Up Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overhaul Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Compression . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Ignition (Using Engine Starter) . . . . . . . . . . . .
Check Carburetion . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment Affecting Engine Operation . . . . . . . . . . . . . . .
Hard Starting, or Will Not Start . . . . . . . . . . . . . . . . .
Vibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Noise . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
7
2. Remove dipstick by rotating cap counterclockwise 1/4 turn
(Fig. 1).
8
8
3. Wipe dipstick and insert it into oil fill tube. Rotate cap
clockwise 1/4 turn. Then remove dipstick and check level
of oil (Fig. 1). If level is low, add only enough oil to raise
level to FULL mark on dipstick. DO NOT FILL ABOVE
FULL MARK BECAUSE ENGINE COULD BE
9
10
12
12
12
12
12
13
13
13
13
DAMAGED WHEN STARTED. POUR OIL SLOWLY.
4.
Insert dipstick into oil fill tube and rotate cap clockwise
1/4 turn to lock (Fig. 1).
4
3
Oil
Oil Specifications
Service classification . . . SF, SG, SH, or SI
Viscosity grade . . . . . . . . SAE 30
Oil capacity . . . . . . . . . . . . 22 fl. oz. (.65 Liter)
2
1
m–3845
Fig. 1 – Checking Oil Level
26 fl. oz. (.78 Liter) with filter
1.
2.
Oil fill tube
Dipstick
3.
4.
ADD mark
FULL mark
Check oil . . . . . . . . . . . . . . before each use or every five
hours.
Change oil . . . . . . . . . . . . . after the first five hours;
thereafter, every 50 operating
hours or every season.
Change Oil
Change the oil after the first 5 operating hours. Thereafter,
change the oil every 50 operating hours or every season. More
frequent oil changes are required when operating engine under
a heavy load, or when used in dusty, dirty, or hot conditions.
Change filter . . . . . . . . . . . on models so equipped,
every 100 operating hours or
yearly, whichever occurs first.
Replace the oil filter (on models so equipped) every 100 hours
or yearly, whichever occurs first.
There are two methods of changing engine oil, the drain plug
method and the oil fill tube method. Both work equally well.
GTS 200
5
General Information
| Categories | Lawn Mower Manual, Parts and Accessories Manuals, Toro Lawn Mower Manual |
|---|---|
| Tags | Toro GTS 200 |
| Download File |
|
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)