Replace Hydraulic Oil Filter
Initially, change filter after the first 50 operating hours,
thereafter, every 800 operating hours, annually, or on in-
dication. Use Toro replacement filter (Part No.
86−6110).
2
IMPORTANT: Use of any other filter may void the
warranty on some components.
1.
Remove seat lock pin, raise seat and hold open with
support rod. Also remove front panel (secured with mag-
nets) ahead of the seat.
2.
Place drain pan under filter and remove filter.
Clean area around filter mounting area (Fig. 95).
1
3.
Lubricate new filter gasket and fill the filter with hy-
draulic oil.
Figure 95
1.
Hydraulic oil filter
2.
Steering pump
4.
Assure filter mounting area is clean. Screw filter on
until gasket contacts mounting plate. Then tighten filter
one−half turn.
NOTE: Under certain conditions, a bypass valve in the
filter mounting plate allows oil to bypass the filter. Before
the filter starts to bypass a warning light on the steering
console will illuminate. The warning light may come on
momentarily when the oil is cold. If the light does not go
out after the oil is warm, the filter is clogged or an electri-
cal problem exists. Correct problem before commenc-
ing operation.
5.
Start engine and let run for about two minutes to
purge air from the system. Stop the engine and check for
leaks.
6.
Check hydraulic oil level (see Check Hydraulic Sys-
tem Fluid).
Replace Hydraulic System Breather
Change hydraulic system breather after every 800 oper-
ating hours, or annually, whichever comes first. More
often in extremely dusty or dirty conditions.
1
2
1.
Release latches and open engine cover.
2.
Clean around the breather and unscrew it with a
wrench. Install new breather (Fig. 96).
3.
Close engine cover and latch securely.
Figure 96
1.
Breather
2.
Exhaust shield
Replace Hydraulic LInes and Hoses
Check hydraulic lines and hoses daily for leaks, kinked
lines, loose mounting supports, wear, loose fittings,
weather deterioration and chemical deterioration. Make
all necessary repairs before operating.
Reelmaster 4000−D
Page 4 − 91
Hydraulic System
| Categories | Lawn Mower Manual, Sprinkler and Irrigation Manuals, Toro Sprinkler and Irrigation Manuals |
|---|---|
| Tags | Toro 4000 D, Toro 98958SL |
| Download File |
|
| Document Type | Catalog |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)