ENGINE REMOVAL AND INSTALLATION
5.
On most models, the fuel tank is mounted at 3
points with capscrews and locknuts on two of the
points, the third point is a pin on the chassis that
goes through a rubber grommet (Figure 53) on the
bottom of the tank. CCR1000’s use a tongue and
groove system and one (Figure 54) mounting
screw. Remove them and lift the tank out. Now
disconnect the fuel line. Caution: If the tank had
fuel in it, there will be some remaining in the fuel
line. Be prepared to clamp the end of the fuel line
or drain it. Note: Do not use a screw or bolt to
plug the end of the fuel line. The threads can
damage the inside of the fuel line and prevent it
from sealing.
A
B
Figure 54
1854-14
(A) Screw
(B) Fuel Tank
D
6.
7.
Disconnect the wiring to the switch and the primer
line.
A
Tie a knot in the starter rope BETWEEN the
control panel and the engine. The knot in the
starter handle can now be untied and the rope
pulled through the control panel. (A slip knot is
recommended, it can be untied, at any time, by
merely pulling on the rope.)
C
B
8.
9.
Remove the locknut connecting the engine
stabilizer bracket to the recoil starter. You may
wish to loosen the bracket at the other end to pivot
it away from the engine.
Figure 53
1854-18
(A) Stabilizer Bracket
(B) Recoil Starter
(C) Rubber Grommet
(D) Pin
Remove the belt cover and roll the belt off the
engine pulley. Loosen the 2 set screws, remove
the engine pulley and key (Figure 55).
4 - 8
Single Stage Snowthrower Service Manual
(3 votes, average: 4.67 out of 5)
Lawn and Garden readers have rated Toro Single Stage Snow Blower Service Manual 4.7 out of 5.0 based on 3 product reviews. EXCELLENT . Hard to find manual and very detailed . Only downside is the pics and wording in pics are backwards , but I can deal with that
The manual provides detailed step-by-step instructions for engine removal and installation but there is nothing in it about repair of the recoil starter. The engine removal instructions will be helpful because the starter is buried behind the fuel tank and engine support bracket. I think my problem is a sticking starter dog but getting to it will be a major project.
manual downloak for toro snwo thorower, downlod manual for toro