ELECTRIC START SYSTEM
12.
Remove the second starter bolt and remove the
starter assembly, wire harness, and starter switch
box (Figure 148).
2.
Remove the three screws from the front of the
upper shroud, located between the directional
vanes (Figure 149).
A
A
B
Figure 148
1854-10
Figure 149
2261-06-2
(A) Starter Mounting Bolt
(B) Motor
(A) Screws
Installation
3.
Remove the gas cap and cover the fuel tank
opening with a clean plastic bag and rubber band
to prevent debris from entering.
Reverse the removal procedures. Note: Incorrect
routing of the wire harness can cause electrical shock.
Route and fasten the wire harness away from all
moving parts.
4.
Remove the two self-tapping screws from either
side of the upper shroud to the handle and remove
upper shroud (Figure 150).
SNOWMASTER 20”, 5200 – 5620/
TECUMSEH AH520 STARTER REMOVAL
A
1.
Drain the fuel from the fuel tank using a pump type
siphon. Caution: Ignition of fuel can result in
severe personal injury of death. Store fuel in an
authorized fuel storage container.
Figure 150
2261-06-3
(A) Screws
5.
Disconnect the spark plug wire from the spark
plug to prevent accidental starting.
6 - 6
Single Stage Snowthrower Service Manual
(3 votes, average: 4.67 out of 5)
Lawn and Garden readers have rated Toro Single Stage Snow Blower Service Manual 4.7 out of 5.0 based on 3 product reviews. EXCELLENT . Hard to find manual and very detailed . Only downside is the pics and wording in pics are backwards , but I can deal with that
The manual provides detailed step-by-step instructions for engine removal and installation but there is nothing in it about repair of the recoil starter. The engine removal instructions will be helpful because the starter is buried behind the fuel tank and engine support bracket. I think my problem is a sticking starter dog but getting to it will be a major project.
manual downloak for toro snwo thorower, downlod manual for toro