Flush Hydraulic System
IMPORTANT: Flush the hydraulic system any time
there is a severe component failure or the system is
contaminated. Contaminated oil appears milky,
black, or contains metal particles.
1
1.
Park machine on a level surface. Stop engine, apply
parking brake, and remove key from ignition switch.
2.
Clean area around filter mounting area (Fig. 13). Re-
move filter and drain filter into a suitable container. Dis-
card filter.
3.
Remove drain plug from transaxle (Fig. 14) and drain
transaxle into a suitable container.
4.
Drain hydraulic system. Drain all hoses and compo-
nents while the system is warm.
Figure 13
1.
Hydraulic filter
5.
Make sure filter mounting surface is clean. Apply
Dexron III ATF to gasket on new filter. Screw filter on un-
til gasket contacts mounting plate, then tighten filter one
half turn further.
6.
Reinstall all hoses and components.
NOTE: Use only hydraulic fluid specified in Operator’s
Manual. Other fluid could cause system damage.
2
7.
Fill transaxle with new hydraulic fluid (see Operator’s
Manual).
8.
engine from starting.
Disconnect and ground spark plug wires to prevent
1
3
9.
Turn ignition key switch to start; engage starter for
ten (10) seconds to prime hydraulic pump. Repeat this
step again.
Figure 14
1.
2.
Transaxle drain plug
Dipstick/filler
3. Strainer
10.Reconnect
spark plug wires.
11.
Start engine and run at idle speed for a minimum of
two (2) minutes.
12.Increase
engine speed to high idle for minimum of
one (1) minute under no load.
13.Turn
steering wheel in both directions several times.
14.Shut
off engine and check for oil leaks. Check oil lev-
el in transaxle and add correct oil if necessary.
15.Operate
the machine for two (2) hours under normal
operating conditions.
16.Check
condition of hydraulic oil. If the fluid shows any
signs of contamination repeat steps 1 through 12 again.
17.Resume
normal operation and follow recommended
maintenance intervals.
Multi Pro 1200/1250
Page 4 – 17
Hydraulic System
| Categories | Lawn Mower Manual, Sprinkler and Irrigation Manuals, Toro Sprinkler and Irrigation Manuals |
|---|---|
| Tags | Toro Multi Pro 1200, Toro Multi Pro 1250 |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)