Preparation for Seasonal Storage
Traction Unit
Traction Unit Engine
1.
oughly.
Cleantractionunit,cuttingunits,andtheenginethor-
1. Drainengineoilfromtheoilpanandreplacethedrain
plug.
2.
(0.97
Check tire pressure. Inflate all tires to 14 to 18 psi
to 1.24 Bar).
2. Remove and discard oil filter. Install new oil filter.
3.
Refill oil pan with approximately 4.0 quarts (3.8 l) of
3.
Check all fasteners for looseness; tighten as neces-
SAE10W-30 motor oil.
sary.
4.
Start engine and run at idle speed for approximately
4.
Lubricate all grease fittings and pivot points (see Lu-
two minutes.
brication).
5.
6.
and water/fuel separator (see Water/Fuel Separator
and Fuel System in Chapter 3 -- Kubota Diesel Engine).
Stop engine.
Drain all fuel thoroughly from the fuel tank, fuel lines,
5.
a light oil to prevent rust. After storage, wipe off all oil.
Cover entirelengthoftheSidewinder cross tubewith
6.
Lightly sand and use touch--up paint on painted
areas that are scratched, chipped, or rusted. Repair any
dents in the metal body.
7.
Fuel System in Chapter 3 -- Kubota Diesel Engine).
Flush the fuel tank with fresh, clean diesel fuel (see
7.
Service battery and cables as follows:
8.
9.
vice Air Filter, Dust Cup, and Burp Valve in Chapter 3 --
Kubota Diesel Engine).
Re--secure all fuel system fittings.
A. Remove battery terminals from the battery posts
(see Battery Service in Chapter 5 -- Electrical Sys-
tem).
Cleanandservicetheaircleanerassembly(seeSer-
B. Clean battery, terminals, and posts with a wire
brush and baking soda solution.
10.Seal
weatherproof tape.
air cleaner inlet and the exhaust outlet with
C. CoatcableterminalsandbatterypostswithGrafo
11.
Check anti--freeze protection and add as needed for
112X
skin--over grease (Toro Part No. 505-47) or pe-
expected minimum temperature in your area (see
CheckCoolingSysteminChapter3 -- KubotaDieselEn-
gine).
troleum jelly to prevent corrosion.
D. Every 30 days, check battery electrolyte levels
and fill battery as necessary (see Battery Care in
Chapter 5 -- Electrical System).
E. Every 60 days, recharge battery slowly for 24
hours to prevent sulfate from forming on the battery
plates (see manufacturer’s instructions for battery
charger).
Groundsmaster 3500--D
Product Records and Maintenance
Page 2 -- 11
| Categories | Lawn Mower Manual, Sprinkler and Irrigation Manuals, Toro Sprinkler and Irrigation Manuals |
|---|---|
| Tags | Toro Groundsmaster 3500 D |
| Download File |
|
| Document Type | Catalog |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)