Preparation for Seasonal Storage
Traction Unit
Traction Unit
1.
oughly.
Clean traction unit, cutting units, and the engine thor-
1. Drain engine oil from the oil pan and replace the drain
plug.
2.
Check tire pressure. Inflate all tires to 14 to 18 psi
2. Remove and discard oil filter. Install a new oil filter.
(0.97
to 1.24 Bar).
3.
Refill oil pan with approximately 4.0 quarts (3.8 l) of
3.
Check all fasteners for looseness; tighten as neces-
SAE10W-30 motor oil.
sary.
4.
Start engine and run at idle speed for approximately
4.
Lubricate all grease fittings and pivot points (see Lu-
two minutes.
brication).
5.
6.
and water/fuel separator (see Water/Fuel Separator
and Fuel System in Chapter 3 − Kubota Diesel Engine).
Stop engine.
Drain all fuel thoroughly from the fuel tank, fuel lines,
5.
Cover entire length of the Sidewinder (Model 03201)
cross tube with a light oil to prevent rust. After storage,
wipe off all oil.
6.
areas that are scratched, chipped, or rusted. Repair any
dents in the metal body.
Lightly sand and use touch−up paint on painted
7.
Fuel System in Chapter 3 − Kubota Diesel Engine).
Flush the fuel tank with fresh, clean diesel fuel (see
8.
9.
vice Air Filter, Dust Cup, and Burp Valve in Chapter 3 −
Kubota Diesel Engine).
Re−secure all fuel system fittings.
7.
Service battery and cables as follows:
Clean and service the air cleaner assembly (see Ser-
A. Remove battery terminals from the battery posts
(see Battery Service in Chapter 5 − Electrical Sys-
tem).
10.Seal
weatherproof tape.
air cleaner inlet and the exhaust outlet with
B. Clean battery, terminals, and posts with a wire
brush and baking soda solution.
11.
Check anti−freeze protection and add as needed for
C. Coat cable terminals and battery posts with Grafo
expected minimum temperature in your area (see
Check Cooling System in Chapter 3 − Kubota Diesel En-
gine).
112X
troleum jelly to prevent corrosion.
skin−over grease (Toro Part No. 505-47) or pe-
D. Every 30 days, check battery electrolyte levels
and fill battery as necessary (see Battery Care in
Chapter 5 − Electrical System).
E. Every 60 days, recharge battery slowly for 24
hours to prevent sulfate from forming on the battery
plates (see manufacturer’s instructions for battery
charger).
Product Records and Maintenance
Reelmaster 3100−D
Page 2 − 10
| Categories | Lawn Mower Manual, Sprinkler and Irrigation Manuals, Toro Sprinkler and Irrigation Manuals |
|---|---|
| Tags | Toro Reelmaster 3100-D |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)