8.
Always wear substantial shoes. Do not operate ma-
11.Fill fuel tank with diesel fuel before starting engine.
Avoid spilling any fuel. Since fuel is highly flammable,
handle it carefully.
chine while wearing sandals, tennis shoes or sneakers.
Do not wear loose fitting clothing because it could get
caught in moving parts and possibly cause personal in-
jury.
A. Use an approved fuel container.
B. Do not remove cap from fuel tank when engine is
hot or running.
9.
and a helmet is advisable and required by some local or-
dinances and insurance regulations.
Wearing safety glasses, safety shoes, long pants
C. Do not smoke while handling diesel fuel.
10.Make
might be picked up and thrown by the reels.
sure the work area is clear of objects which
D. Fill fuel tank outdoors and not over one inch from
the top of the tank, (bottom of the filler neck). Do not
overfill.
While Operating
12.Do
quate ventilation. Exhaust fumes are hazardous and
could be deadly.
not run the engine in a confined area without ade-
starts. Use reverse pedal for braking. Cutting units must
be lowered when going down slopes for steering control.
18.When
starting the engine:
13.Sit
chine.
on the seat when starting and operating the ma-
A. Engage parking brake.
B. Be sure traction pedal is in neutral and reel drive
is in disengage position.
14.Check
interlock switches daily for proper operation
(Chapter 5 − Electrical System). Do not rely entirely on
safety switches -shut off engine before getting off seat.
If a switch fails, replace it before operating the machine.
The interlock system is for your protection, so do not by-
pass it. Replace all interlock switches every two years.
C. After engine starts, release parking brake and
keep foot off traction pedal. Machine must not move.
If movement is evident, the neutral control linkage is
incorrectly adjusted: therefore, shut engine off and
adjust until machine does not move when traction
pedal is released (see Adjust Transmission for Neu-
tral).
15.Operator
must be skilled and trained in how to drive
on hillsides. Failure to use caution on slopes or hills may
cause vehicle to tip or roll, possibly resulting in personal
injury or death. Always wear your seat belt.
19.Before
backing up, look to the rear and assure no
one is behind the machine. Watch out for traffic when
near or crossing roads. Always yield the right of way.
16.This
triplex mower has a unique drive system for su-
perior traction on hills. The uphill wheel will not spin out
and limit traction like conventional triplexes. If operated
on a side hill that is too steep, rollover will occur before
losing traction.
20.Keep
hands, feet and clothing away from moving
parts and the reel discharge area. Grass baskets, if so
equipped, must be in place during reel operation for
maximum safety.
17.The
slope angle at which the machine will tip is de-
pendent on many factors. Among these are mowing
conditions such as wet or undulating turf, speed (espe-
cially in turns), position of the cutting units (with side-
winder), tire pressure and operator experience. At side
hill slope angles of 20 degrees or less the risk of a rol-
lover is low. As the slope angle increases to a Toro rec-
ommended maximum limit of 25 degrees the risk of a
rollover increases to a moderate level. DO NOT EX-
CEED A 25 DEGREE SIDE HILL ANGLE BECAUSE
THE RISK OF A ROLLOVER AND SERIOUS INJURY
OR DEATH IS VERY HIGH. Stay alert for holes in terrain
and other hidden hazards. Use extreme caution when
operating close to sand traps, ditches, creeks, steep hill-
sides or other hazards. Reduce speed when making
sharp turns. Do not turn on hills. Avoid sudden stops and
21.This
product may exceed noise levels of 85 dB(A) at
the operator position. Ear protectors are recommended
for prolonged exposure to reduce the potential of per-
manent hearing damage.
22.Raise
area to another.
the cutting units when driving from one work
23.Do
not touch engine, muffler, exhaust pipe or hydrau-
lic tank while engine is running or soon after it has
stopped because these areas could be hot enough to
cause burns.
Safety
Reelmaster 3100−D
Page 1 − 2
| Categories | Lawn Mower Manual, Sprinkler and Irrigation Manuals, Toro Sprinkler and Irrigation Manuals |
|---|---|
| Tags | Toro Reelmaster 3100-D |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)