Assembly (Fig. 40)
Put flange on a flat surface with shaft seal facing
down. Make sure back side of flange is free of contami-
nation.
7. Carefullyinstallgearhousingoverrearbearingblock
and slide gear housing down over the gears and front
bearing block.Makesure themarkings puton theflange
and housing earlier line up.
1.
8.
The rear bearing block should sit just below back
2.
3.
block. Put tape or seal protector tool (TOR4072) over
splined end of drive shaft. Insert drive shaft through
bearing block and shaft seal.
Put front bearing block, seal side down, on flange.
Apply a light coating of oil to exposed face of bearing
faceofgearhousing.Ifbearingblocksitshigherthatrear
face of housing, remove gear housing and check that E-
seal or O-ring did not shift out of place during assembly.
9.
ing, then put end cover on back of motor.
Install remaining two dowel pins in rear of gear hous-
4.
of oil to back face of drive and idler gears.
Put idler gear on bearing block. Apply a light coating
10.After
by hand. Tighten the capscrews evenly in a crossing
motor has been assembled, tighten capscrews
pattern to 40 to 45 ft-lb (54 to 61 N--m).
5.
Put rear bearing block, seal side up, on drive and
idler gear shafts.
11.
Put a small amount of hydraulic oil in port on motor
and rotate driveshaft one revolution. Protect the shaft if
using a pliers. If drive shaft binds, disassemble motor
and repeat assembly process.
6.
Install the two front dowel pins in the flange.
Reel Motor (Bosch)
35
(47
to 40 ft--lb
to 55 N--m)
1
1 to 15 ft--lb
18
(15
to 20 N--m)
17
16
15
10
7
13
15
8
12
2
16
6
7
17
3
1
6
18
5
12
9
11
(15
to 15 ft--lb
to 20 N--m)
14
5
4
11
19
Figure 42
1.
2.
3.
4.
5.
6.
7.
Rear Cover
Drive Gear
Seal
Washer (if used)
Pressure Seal
Back--up Ring
O--ring
8.
9.
10. Cap Screw (4 used)
11. Front Flange
12. Dowel Pin
13. Rear Bearing Block
Body
14. Front Bearing Block
15. O-ring
Idler Gear
16. O-ring
17. Back--up Ring
18. Relief Cartridge
19. Retaining Ring
Hydraulic System
Page 4 - 70 Rev. E
Reelmaster 6500-D/6700-D
| Categories | Lawn Mower Manual, Toro Lawn Mower Manual |
|---|---|
| Tags | Toro Reelmaster 6500-D, Toro Reelmaster 6700-D |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Product Type | Walk Behind Mower |
| Engine Manufacturer | Toro |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)