Note:
this section of this manual for additional information.
See Leak Detector Troubleshooting Guide in
S Alarm short circuit (LED blinking): Check/replace
TurfDefender alarm or wires.
1.
Park machine on a level surface and engage the
parking brake.
1
2.
Open control panel cover.
Locate leak detector harness loopback connector
with hydraulic symbol tag. Carefully unplug loopback
connector from harness connector.
Figure 11
1. Electric solenoid valve
3.
Connect the Diagnostic ACE display connector to
the correct harness loopback connector. Install TurfDe-
fender overlay decal (supplied with leak detector kit) on-
to Diagnostic ACE (Fig. 13).
If 4 beeps are heard:
The most common cause for a 4 beep signal is from an
improper oil level reading. Make sure machine is on a
level surface when checking oil level. Since oil level will
vary with temperature, it is best to check when cool.
1. When toggling “input”, a LED should display
(Fig. 14)anyofthefollowing problemsdiagnosed bythe
TurfDefender:
4.
position.
The ignition key switch must be turned to the “ON”
Note:
and green text refers to outputs.
Red text on the overlay decal refers to inputs
5.
The red “Inputs displayed” LED (Light Emitting
Diode), on lower right column of the Diagnostic ACE,
should be illuminated. If green “Outputs displayed” LED
is illuminated, press and release the toggle button, on
Diagnostic ACE, to change LED to “Inputs displayed”.
Do not hold button down (Fig. 13).
S Oil level low: Position machine on a level surface
and fill to proper level.
S Oil level high: Position machine on a level surface
and remove excess oil until proper level is attained.
S Air leak in system: Assure tank cap is tight or check
for leak in tank.
If TurfDefender is functioning normally:
1.
Float position (1 or 2 LED’s on left side) and “Oil level
OK” LED (right side) -- should be displayed (Fig. 14).
When the “Inputs displayed” LED is lit, the actual
Note:
Only large air leaks can be detected by hand
held Diagnostic ACE. A leakdown test is required to
identify small air leaks. Consult your Authorized Toro
Distributor for assistance.
2.
Press toggle button until green “Outputs displayed”
LED is lit. “Valve ON”, “data line” and ”self diagnos-
tic”LED’s should be lit steadily. “Alarm ON” LED may be
displayed temporarily (about 5 seconds) (Fig. 15).
2.
(Fig. 15)anyofthefollowing problemsdiagnosed bythe
TurfDefender:
When toggling “output” a LED should display
Note:
blinking, there is a problem in the system.
If “data line” or ”self diagnostic” LED’s are
S Valve open circuit (LED blinking): Check/replace
TurfDefender electric solenoid valve or wires
(Fig. 11).
If No beeps are heard:
1.
nected, broken or “+” and “--” reversed.
Check alarm wires to make sure they are not discon-
S Valve short circuit (LED blinking): Check/replace
TurfDefender electric solenoid valve or wires
(Fig. 11).
2.
in.
Make sure TurfDefender 4--pin connector is plugged
Make sure TurfDefender 5 amp fuse (fuse block “B”,
S Self diagnostic LED Blinking: Internal circuit failure
in TurfDefender. Consult your Authorized Toro Dis-
tributor for assistance.
3.
slot #3) is not blown.
S Data Line LED Blinking: Problem with communica-
tions between machine and leak detector; or prob-
lem with wires. Consult your Authorized Toro
Distributor for assistance.
4.
Toggle “outputs displayed” on Diagnostic ACE dis-
play (Fig. 15).
S Drip Drop LED Blinking: A slow oil leak (level drop)
may be detected.
S Alarm open circuit (LED blinking): Check/replace
TurfDefender alarm or wires.
Reelmaster 6500-D/6700-D
Electrical System (Rev. C)
Page 5 - 9
| Categories | Lawn Mower Manual, Toro Lawn Mower Manual |
|---|---|
| Tags | Toro Reelmaster 6500-D, Toro Reelmaster 6700-D |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Product Type | Walk Behind Mower |
| Engine Manufacturer | Toro |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)