IMPORTANT: Thedisplaywillshoweight(8)individ-
ual records with the fault displayed on the 8th re-
cord. Each record will be displayed for 10 seconds.
Be sure to have theDiagnostic Tool display on Out-
puts to see fault. The Problem circuit will be flash-
ing. Records will repeat until key is turned off. Unit
will not start in this mode.
3. Turn the Reel Control Switch to Enable position.
4.
Move the Joystick to the Raise position and hold.
5.
Joystick in the Raise position until the Reel Control
Turn the ignition key to On, and continue to hold the
Lamp starts to flash (approx. 2 seconds).
6.
is now cleared.
Release the Joystick and turn the Key Off. Memory
Clearing the Fault Memory
(Diagnostic Tool not required)
1.
Rotate ignition key to Off position.
7.
Turn the Backlap Switch to Off and Enable Switch to
Disable position.
2.
Turn Backlap Switch to the Front or Rear Backlap
position.
TurfDefender Leak Detector
The TurfDefendert is an electronic hydraulic fluid leak
detectiondevicethatfitsinsidethehydraulictankofyour
machine. Itisapressure based system which requires a
sealed hydraulic tank to function properly. Very small
changestotheoillevelinthesealedtankresultinalarge
movement of the leak detector’s internal float. The Turf-
Defender’s internal microprocessor analyzes the float
movement and determines if there is a leak in the sys-
tem.
1
S Turn ignition key to “ON” position start the system.
The system will reset itself whenever the ignition
key is moved to “OFF” position. Wait 5 seconds,
then move key to “ON” position to restart the sys-
tem.
Figure 10
1.
Alarm
Checking Leak Detector Operation
S When machine is started, the alarm will give one
short beep to indicate that everything is operating
properly. If the alarm makes no noise at all, it should
be checked.
The operation of the TurfDefendert
checked if any of the following conditions occur:
should be
Note:
The hand held Diagnostic ACE can be used to
identify many of the problems.
S If the alarm gives 4 short beeps it means a system
problem has been detected and it should be
checked.IftheTurfDefendert isprogrammedwith
software revisions -- A, B, C, D or E, the alarm will
continue the 4 beep pattern for approximately 1.5
minutes,andthenstop.Ifitisprogrammedwithrevi-
sion level F or above, the alarm will repeat the 4
beep pattern twice, and then cease to give further
error indication until another fault is detected. In ei-
ther case, once the ignition key is moved to the
“OFF” position, all alarm reports will cease.
A. No beeps are heard when ignition switch is
turned “ON”.
B. Any time the machine gives a series of 4 short
beeps.
C. False alarms are observed.
Note:
The Diagnostic ACE may have to be connected
before shutting off the ignition key in order to identify the
problem.
Note:
Theloworhighoillevel4beepsignalmayoccur
ifmachine isstarted onaslope.Move machine toalevel
surface, move ignition key to “OFF” position, wait 5
seconds, then move key to “ON” position to restart the
system.
WARNING
To identify some problems, engine may have
to be running. To guard against possible per-
sonal injury, engage parking brake and keep
hands, feet, face and other parts of the body
away from moving parts.
S If the alarm gives long continuous beeps while
mowing and shuts off the cutting units, it means that
a leak has been detected. On the Reelmaster trac-
tion unit, the red diagnostic lamp on the steering
console will also blink indicating the Reelmaster
electronic controller has shut off the cutting unit’s.
Electrical System (Rev. C)
Reelmaster 6500-D/6700-D
Page 5 - 8
| Categories | Lawn Mower Manual, Toro Lawn Mower Manual |
|---|---|
| Tags | Toro Reelmaster 6500-D, Toro Reelmaster 6700-D |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Product Type | Walk Behind Mower |
| Engine Manufacturer | Toro |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)