Service and Repairs
Battery Service
The battery is the heart of the electrical system. With
regular and proper service, battery life can be extended.
Additionally, battery and electrical component failure
can be prevented.
Inspection, Maintenance and Testing
Perform the following inspection and maintenance
1.
tasks:
A. Check for cracks caused by overly tight or loose
hold–down clamp. Replace battery if cracked and
leaking.
Note:
322/325
with serial number below 21000000 is included in Chap-
ter 6.
Battery information for all Groundsmaster
machines and Groundsmaster 345 machines
B. Check battery terminal posts for corrosion. Use
a terminal brush to clean corrosion from the battery
terminal posts.
Electrolyte Specific Gravity
Fully charged: 1.265 corrected to 80o F (26.7o C)
Discharged: less than 1.240
IMPORTANT: Before cleaning the battery, tape or
block the vent holes to the filler caps and make sure
the caps are on tightly.
Battery Specifications Groundsmaster 328–D
BCI Group 24
660
110
Amp Cranking Performance at 0o F (–17.8o C)
Minute Reserve Capacity at 80o F (26.7o C)
FILLER CAPS
CAP TUBES
Battery Specifications Groundsmaster 345
CORRECT
WATER
LEVEL
BCI Group 24
420
67
Amp Cranking Performance at 0o F (–17.8o C)
Minute Reserve Capacity at 80o F (26.7o C)
COVER SEAL
CAUTION
Figure 14
Wear safety goggles and rubber gloves
when working with electrolyte. Charge
the battery in a well ventilated so gases
produced while charging can dissipate.
Since the gases are explosive, keep open
flame and electrical spark away from the
battery; do not smoke. Nausea may
result if the gases are inhaled. Unplug
charger from electrical outlet before con-
necting to, or disconnecting charger
leads from battery posts.
C. Check for signs of wetness or leakage on the top
of the battery which might indicate a loose or mis-
sing filler cap, overcharging, loose terminal post or
overfilling. Also, check the battery case for dirt and
oil. Clean the battery with a solution of baking soda
and water, then rinse it with clean water.
D. Check that the cover seal is not broken away.
Replace the battery if the seal is broken or leaking.
E. Check the electrolyte level in each cell. If the lev-
el is below the tops of the plates in any cell, fill all
cells with distilled water to the bottom of the cap
tubes. Charge at 15 to 25 amps for 15 minutes to al-
low sufficient mixing of the electrolyte.
Electrical System (Rev. G)
Page 6A – 12
Groundsmaster 300 Series
| Categories | Lawn Mower Manual, Sprinkler and Irrigation Manuals, Toro Sprinkler and Irrigation Manuals |
|---|---|
| Tags | Toro Groundsmaster 300, Toro Groundsmaster 328 D, Toro Groundsmaster 92801SL |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(2 votes, average: 5 out of 5)
Lawn and Garden readers have rated Toro 92801SL Rev I Groundsmaster 300 Series Groundsmaster 328 D Service Manual 5.0 out of 5.0 based on 2 product reviews. Need 328D. Manual pdf. Will rate after finding manual
t has been a very reliable machine but getting parts is hard and not cheap to buy , generic parts has been cost effective and reliable , i am unable to get a wiring circut diagram for this unit as most problems are electrical problems