Rear Axle Removal and Installation
45 - 55 ft-lb
Figure 10A
Figure 10B
1. Remove drain plugs from axle and allow oil to drain
into a container (Fig. 2).
8. Remove nut (Fig. 10A, Item 14) and flatwasher
(Item 15). Remove capscrews (Item 6) from pin
(Item 7). Remove the pin. This will release the rear axle
and washers from the support (Item 9). Carefully pull the
axle out from under the machine.
2. Remove drive shaft (see Drive Shaft Service).
3. Disconnect clutch engagement cable from rear axle.
NOTE: A varying number of washers (Fig. 10B, Item 41,
42) may have been installed between the axle pivot and
axle support during manufacture. Make sure the same
number of washers are installed during reassembly.
4.
Thoroughly clean around hydraulic hoses connec•
tions to steering cylinder. Mark hoses so they will be
installed correctly during reassembly. Disconnect hoses
from fittings on steering cylinder. Put plugs or caps on
open hoses and fittings to prevent contamination of
hydraulic system.
9. Reverse steps 1 - 8 to install axle. The washers
(Fig. 10B, Item 41, 42) must be positioned between the
front end of the axle pivot and the axle support (see the
NOTE above). Make sure thrust washer (Fig. 10B,
Item 14) is installed between rear end of axle pivot and
the axle support.
5. Loosen rear wheel capscrews (Fig. 10A, Item 23).
6. Block front tires and jack up rear of machine until there
is approximately one inch clearance between rear tires
and the ground. SECURELY BLOCK FRAME.
7. Remove rear wheels.
Groundsmaster® 300 Series
Page 10 - 7
Repairs
| Categories | Lawn Mower Manual, Sprinkler and Irrigation Manuals, Toro Sprinkler and Irrigation Manuals |
|---|---|
| Tags | Toro Groundsmaster 300, Toro Groundsmaster 328 D, Toro Groundsmaster 92801SL |
| Download File |
|
| Document Type | Service Manual |
| Language | English |
| Product Brand | Toro. Customer Service Representatives are available by phone:
Monday - Friday 7:30 a.m. to 9:00 p.m. (CDT) - Saturday 8:00 a.m. to 8:00 p.m. (CDT) - Sunday 10:00 a.m. to 8:00 p.m. (CDT)
Canada 1-888-225-4886 USA 1-888-384-9939, Lawn Mower |
| Document File Type | |
| Publisher | toro.com |
| Wikipedia's Page | Toro Company |
| Copyright | Attribution Non-commercial |
(2 votes, average: 5 out of 5)
Lawn and Garden readers have rated Toro 92801SL Rev I Groundsmaster 300 Series Groundsmaster 328 D Service Manual 5.0 out of 5.0 based on 2 product reviews. Need 328D. Manual pdf. Will rate after finding manual
t has been a very reliable machine but getting parts is hard and not cheap to buy , generic parts has been cost effective and reliable , i am unable to get a wiring circut diagram for this unit as most problems are electrical problems